Keywords
drop-count
ethanol
hand sanitiser
oxalic acid
potassium permanganate
How to Cite
Abstract
Introduction
The demand for ethanol-based sanitisers has increased dramatically since the dawn of the COVID-19 era, making it very difficult for health regulators to ensure the quality of the products and the safety of unsuspecting consumers. This article reports the development and application of a simple 'drop-count' titrimetry method for the determination of ethanol in hand sanitisers.
Materials and Methods
This method follows the classical potassium permanganate-oxalic acid titrimetry but uses very small volumes of the reagents – 0.5 mL of ethanol sample solution, 6 mL of acidified 0.1 M potassium permanganate, and a few counted drops of 0.1M oxalic acid.
Results
This method achieved satisfactory figures of merit, namely, linearity (R2 ≥ 0.9667), reproducibility, and importantly very little matrix effect in the alcohol concentration range of 50 to 80%.
Conclusion
The small volumes (< 10 mL in total) of the reagents required make this method considerably safe and cost-effective and applicable for fieldwork even by untrained personnel, not just chemists as is often the case for field applications.
References
Berardi, A., Cenci-Goga, B., Grispoldi, L., Cossignani, L., & Perinelli, D. (2020). Analysis of Commercial Hand Sanitisers amid COVID-19: Are We Getting the Products that We Need? AAPS PharmSciTech, 21(7), 1-6. https://doi.org/10.1208/s12249-020-01818-6
Cleveland, D., Carlson, M., Hudspeth, E. D., Quattrochi, L. E., Batchler, K. L., Balram, S. A., et al. (2007). “Raman spectroscopy for the undergraduate teaching laboratory: quantification of ethanol concentration in consumer alcoholic beverages and qualitative identification of marine diesels using a miniature raman spectrometer. Spectroscopy Letters, 40(6). https://doi.org/10.1080/00387010701525638
Cohen, G., Kreutzer, N., Mowat, K., Hassan, A., & Dvorak, B. (2021). Compliance with hand sanitiser quality during the SARS-CoV-2 pandemic: Assessing the impurities in an ethanol plant. Journal of Environmental Management, 297, 113329. https://doi.org/10.1016/j.jenvman.2021.113329
Fonseca, F., Brito, L., Pimentel, M., & Leal, L. (2020). Determination of ethanol in gel hand sanitisers using mid and near infrared spectroscopy. Journal of the Brazilian Chemical Society, 31, 1759-1763. https://doi.org/10.21577/0103-5053.20200115
Kurnia, G. M. (2020, 03 31). UNAIR News:UNAIR expert comments on fake hand sanitisers on market. Retrieved 08 10, 2020, from http://news.unair.ac.id/en/2020/03/31/unair-expert-comments-on-fake-hand-sanitisers-on-market/
Langhals, H. (2020). The quality control of alcoholic components of disinfectants by a simple colour test. South African Journal of Chemistry, 73 , 81-83. http://dx.doi.org/10.17159/0379-4350/2020/v73a12
Matatiele, P., Southon, B., Dabula, B., Marageni, T., Poongavanum, P., & Kgarebe, B. (2022). Assessment of quality of alcohol-based hand sanitisers used in Johannesburg area during the CoViD‐19 pandemic. Scientific Reports, 12(1), 1-7. https://doi.org/10.1038/s41598-022-08117-z
Meden, I.-L. F. (2016, July 10). Determination of Alcohol Content in Alcoholic Beverages Using 45MHz Benchtop NMR Spectrometer. (E. R. Zuiderweg, Ed.) International Journal of Spectroscopy, 2016, 1. https://doi.org/10.1155/2016/2526946
Nogueira, S. A., Lemes, A. D., Chagas, A. C., Vieira, M. L., Talhavini, M., Morais, P. A., & Coltro, W. K. (2019). Redox titration on foldable paper-based analytical devices for the visual determination of alcohol content in whiskey samples. Talanta, 194, 363-369. https://doi.org/10.1016/j.talanta.2018.10.036
Paixão, T., Corbo, D., & Bertotti, M. (2002). Amperometric determination of ethanol in beverages at copper electrodes in alkaline medium. Analytica Chimica Acta, 472(1-2), 123-131. https://doi.org/10.1016/S0003-2670(02)00942-X
Perra, N. (2021). Non-pharmaceutical interventions during the COVID-19 pandemic: A review. Physics Reports, 913, 1-52. https://doi.org/10.1016/j.physrep.2021.02.001
Romer, D., & Jamieson, K. (2020). Conspiracy theories as barriers to controlling the spread of COVID-19 in the US. Social Science & Medicine, 263, 113356. https://doi.org/10.1016/j.socscimed.2020.113356
Science ASSIST Team. (2020, 7 7). Potassium dichromate in the determination of alcohol content in wine. Retrieved from https://assist.asta.edu.au/question/3734/potassium-dichromate-determination-alcohol-content-wine?__cf_chl_jschl_tk__=ce31e18e0f3ec69d1175e04a980ff2830c2d8e4a-1596789012-0-Ab2ZVwi-wsrRqI4hA1OBTydCPwGK_5kBxZuxyCuxAll9rv1ZvStl8rR3dmanRGVi3SP6gD2q9033HFwJ-Vnn
Sriariyanun, M., Charoen, P., Teparaamorndech, S., Cheenkachorn, K., & Rattanaporn, K. (2019). A rapid spectrophotometric method for quantitative determination of ethanol in fermentation products. Oriental Journal of Chemistry, 5(2), 744-750. http://dx.doi.org/10.13005/ojc/350234
U.S. Food and Drug Admistration. (2020, 10 08). Q&A for Consumers | Hand Sanitisers and COVID-19. Retrieved from fda.gov: https://www.fda.gov/drugs/information-drug-class/qa-consumers-hand-sanitisers-and-COVID-19
Authors of articles published in Orap J are the copyright holders of their articles. When they accept our terms of use, they grant any third party the right to use, reproduce or disseminate their article freely without fiscal or registration restrictions.